or Connect
SmokingMeatForums.com › Forums › Smoking Supplies & Equipment › Wood Smokers › Can't Keep the Heat Up!
New Posts  All Forums:Forum Nav:

Can't Keep the Heat Up!

post #1 of 9
Thread Starter 
Hi all. I'm new to the group and hoping for help. I'm in Dallas, TX and use a New Braunfels (Charbroil) Bandera, which has an offset firebox and a large vertical smoke chamber. I've done chickens and a brisket with good results, but I'm not sure I'm doing it exactly right.

Here's my problem: I'm having a hard time keeping my chamber in the 225-250 range -- it's constantly falling below 200 degrees. I'm burning logs of mesquite wood (bought in a big sack at Home Depot), but I seem to be going through them really fast. For your reference, in a 12-hour brisket smoke I went through more than a whole bag (2 cubic feet; about 30 pounds of wood). It seems the only time the smoker stays up to temp is when there's a rather large fire burning (not just coals) so I'm adding more wood every 15-20 minutes. I'm also keeping the air intake open so the coals will burn hotter, but that also makes the wood burn even faster. Finally, I'm keeping the damper nearly closed on top of the chamber to hold the heat in, but I know that's not recommended.

From all I've read on this site and others, it sounds like most people can get their fire going and leave it alone for long stretches (maybe adding a log every 30 minutes to an hour). To summarize, I'm constantly tending the fire in order to stay above 200 degrees. Is this normal, or am I dont something wrong?

Thanks in advance for your advice!
post #2 of 9

Re: Can't Keep the Heat Up!

Hi LB, You will get plenty of help soon! But I think you need to burn a wood with a higher Btu rating like oak, and use the mesquite more for flavoring the smoke (plus mesquite is a very strong tasting wood!) Have you measured the temp on your grate? Hang in there buddy, helps coming!
post #3 of 9
I use charcoal for heat and wood for the smoke flavor.

post #4 of 9

Re: Can't Keep the Heat Up!

Hi LB,

I have a BSKD which is a twin sister to your Bandera. I converted mine to propane to help control it's temp swings, but before I did I always started my smoke with about 10# of Royal Oak charcoal to get a good hot coal bed going and then about once an hour you can use a split of wood to keep adding new coals and continue producing smoke. On long smokes like Briskets and Butts, I have occasionally had to add another chimney full of hot briquets to maintain the coal bed.

I would caution against closing the top vent as you will eventually get a creosote build up in your smoke chamber and everything will taste sooty and bitter :( . Always keep it at least half open.

There are some modifications you can make that are shown in the charcoal smoker forum. These will help you to distribute your heat more evenly in the chamber.

Any other questions be sure and ask.
post #5 of 9

Re: Can't Keep the Heat Up!

Welcome LB,

I have the Chargriller SuperPro with SFB, similar so I might be able to help. Keep your vent wide open, adj the air intake to control the temp.

You might even want to try some oak in there so you won't get too strong of a mesquite taste, unless you like it stronger. I myself do not. Or if you don't want to buy a lot of wood just to burn, try some good quality lump, and supplement it with the mesquite.

I use to use only briquetts, but have all but switched to lump. I have abt 3 bags of briqs left, and then it will be all lump. I have abt 180lbs of lump stored up.

I hope this helps.

post #6 of 9

Re: Can't Keep the Heat Up!

Maybe try ******? :)
It helps to get oxygen in under your coals. A basket or a fire grate might help.
If you're not going to use charcoal I would suggest using oak splits for a base. All mesquite is very strong.
post #7 of 9
I have to agree. With just starting with my first all wood smoker I have found out I need Oak to keep my temps up. About 50% of my burn is oak. It keeps the temps up and I only have to add wood about every 45min to an hour.
post #8 of 9
Thread Starter 
Thanks everyone. All your suggestions sound good. I'll give them a try. As a follow-up question, does anyone have suggestions for where to buy oak? Home Depot, Academy, and some grocery stores around Dallas sell mesquite, hickory, and pecan but I have yet to see any oak. Thanks again.
post #9 of 9

Re: Can't Keep the Heat Up!

Does the state of Texas not grow oak? Look in the classified section of the news paper under firewood. Most people burn oak in their fireplaces and woodstoves because of it's excellent fuel properties. Also, you might refer to this thread. http://www.smokingmeatforums.com/vie...944&highlight=
New Posts  All Forums:Forum Nav:
  Return Home
  Back to Forum: Wood Smokers
SmokingMeatForums.com › Forums › Smoking Supplies & Equipment › Wood Smokers › Can't Keep the Heat Up!