Smoking Brat Help

  • Some of the links on this forum allow SMF, at no cost to you, to earn a small commission when you click through and make a purchase. Let me know if you have any questions about this.
SMF is reader-supported. When you buy through links on our site, we may earn an affiliate commission.

dj54

Fire Starter
Original poster
Jan 1, 2012
52
11
Southwest Louisiana
Need some help from you guys on the how to smoke the brats I made yesterday. They have been in fridge overnight. Got a Cajun Injector electric smoker with electronic control with smoking tray and water pan. Start at what temp ?Use Smoke ? Use Water ? How long ? Thanks again I have gotten hooked on this forum can't stop reading and learning
 
Did you add cure to your Brats? 

Brats are generally a fresh sausage and are not smoked.  Need to be sure there is cure in there before smoking to be sure the meat stays safe.
 
Just remember that you are cooking them in smoker. Since this is a fresh sausage, you'll need to get you internal temps on the sausages to 160°.
 
No. Your fine. Once you take them out of the fridge just get them up to at least 140 under four hours.
and like Dutch said smoke them until IT is 160 degrees.
If you smoke at 225 they will get done well before the 4 hour rule
 
No- the 40 to 140 in 4 is an accumlitive number-anytime the temp gets above 40°, it counts. That is why we grind the meat almost frozen and stuff meat that is ice cold. We're trying to keep the meat below the 40° mark. If you had the meat out and it warmed to the point that it was above 40° for an hour before going into the smoker or back into the fridge you would then only have 3 hours to get the internal temp above 140°.

If you kept everything cold below 40° during the grinding, mixing and stuffing, then you are still good with the 40 to 140 in 4 rule. Always keep a themometer handy and keep whatever you're not grinding, mixing or stuffing in the fridge.
 
  • Like
Reactions: psych
icon_cool.gif


Like Dutch is telling you that you need to smoke the fresh sausage to 160° internal temp. Now you won't have to do this under 4 hours because you will get it to that temp pretty darn fast.
 
No- the 40 to 140 in 4 is an accumlitive number-anytime the temp gets above 40°, it counts. That is why we grind the meat almost frozen and stuff meat that is ice cold. We're trying to keep the meat below the 40° mark. If you had the meat out and it warmed to the point that it was above 40° for an hour before going into the smoker or back into the fridge you would then only have 3 hours to get the internal temp above 140°.

If you kept everything cold below 40° during the grinding, mixing and stuffing, then you are still good with the 40 to 140 in 4 rule. Always keep a themometer handy and keep whatever you're not grinding, mixing or stuffing in the fridge.
Dutch good post ! I will be doing a lot of sausage over next few week. I will make sure to keep meat ice cold during the grind and stuffing.
thanks for info.
 
Dutch good post ! I will be doing a lot of sausage over next few week. I will make sure to keep meat ice cold during the grind and stuffing.
thanks for info.
Don't forget to show and tell!
 
There is a reason some sources tell you all sausage being smoked must be cured.

The problem lies in the definition of smoking.

Much of what we do is hot smoking.  Some sources do not consider that smoking, but rather BBQ.  To the folks at these sources smoking means extended periods of cold smoke.  In that situation, the smoked sausage would require a cure. Here is an example from a well known source:

http://www.wedlinydomowe.com/barbecue

Carefully hot smoke (220 - 250) your fresh brats to 160 (165 for poultry sausage) and you will be fine. With thick chubs of sausage you either need to cure or carefully hit the temp/time guidelines.

Good luck and good smoking.
 
Last edited:
SmokingMeatForums.com is reader supported and as an Amazon Associate, we may earn commissions from qualifying purchases.

Latest posts

Hot Threads

Clicky